新闻资讯

引风机的运转良好是烘干的前提!

2019-08-05 来源:http://www.zhongyanjixie.com 发布人:admin 浏览量:
[导读]:  诱导通风风机是锯末干燥机的重要组成部分,其运行状况对锯末干燥机的工作有很大影响,因此有必要保持诱导通风风机的良好运行。为保证锯
  诱导通风风机是锯末干燥机的重要组成部分,其运行状况对锯末干燥机的工作有很大影响,因此有必要保持诱导通风风机的良好运行。为保证锯末干燥机排风机的良好运行,应注意以下事项:
  Induced ventilation fan is an important part of sawdust dryer. Its operation condition has a great impact on the work of sawdust dryer. Therefore, it is necessary to maintain the good operation of induced ventilation fan. In order to ensure the good operation of exhaust fan of sawdust dryer, the following points should be paid attention to:
  1. 当引风机工作条件发生变化时,应检查引风机的性能。
  1. When the working conditions of the induced draft fan change, the performance of the induced draft fan should be checked.
  2. 定期检查温度计和油标的灵敏度,控制轴承箱油位在允许范围内。
  2. Check the sensitivity of thermometer and oil mark regularly to control the oil level of bearing box within the allowable range.
  3.引风机在启动、停止或运行过程中,如发现引风机有异常现象,应立即检查。检查中发现的小故障,应及时查明原因,设法排除或处理。不能排除小故障或者发现大故障的,应当立即进行检查。
  3. In the process of starting, stopping or running of the induced draft fan, if abnormal phenomena of the induced draft fan are found, it should be inspected immediately. The minor faults found in the inspection shall be promptly ascertained, and the causes shall be eliminated or dealt with. If minor or major faults cannot be eliminated, they shall be inspected immediately.
木屑烘干机厂家
  4. 流量过大,不符合使用要求,或流量过小,在较短时间内,可使用节流阀装置进行调节。
  4. Flow is too large, does not meet the requirements of use, or flow is too small, in a relatively short period of time, throttle valve device can be used to adjust.
  轴承座的传动方式应定期(季度)检查,清洗并加润滑油,以防止轴承烧坏。。
  The transmission mode of the bearing seat should be checked regularly (quarterly), cleaned and lubricated to prevent the bearing from burning out.
  6. 除对引风机拆修后更换润滑油外,还应定期更换润滑油。
  6. In addition to replacing lubricating oil after dismantling and repairing the induced draft fan, the lubricating oil should also be replaced regularly.
  当然,木屑干燥机引风机的稳定运行离不开定期维护。只有采取适当的维修措施,才能有效地防止引风机故障,降低维修成本,提高锯末干燥机的工作性能。
  Of course, the stable operation of sawdust dryer induced draft fan can not be separated from regular maintenance. Only by taking appropriate maintenance measures, can the fault of induced draft fan be effectively prevented, the maintenance cost be reduced and the working performance of sawdust dryer be improved.
返回顶部

版权所有©山东众焱机械有限公司 备案号:鲁ICP备19005667号-1 服务热线:18005415007 流量统计: