新闻资讯

节能锅炉停止的类型以及方法!

2019-07-08 来源:http://www.zhongyanjixie.com 发布人:admin 浏览量:
  锅炉节能停车主要有三种类型:临时停车、正常停车和紧急停车。
  There are three main types of boiler energy-saving parking: temporary parking, normal parking and emergency parking.
  暂停锅炉是指短时间内减少负荷或使用蒸汽机组及设备短时间内暂停使用蒸汽,根据减负荷量和时间长短,暂停部分机组的运行。
  Boiler suspension refers to the short-term reduction of load or the use of steam units and equipment in a short period of time to suspend the use of steam, according to the amount of load reduction and the length of time, suspend the operation of some units.
  正常停机是指锅炉作为生活必需品,在冬季、冬季使用后,应及时停机,以保证锅炉在明年的正常使用。
  Normal shutdown refers to the boiler as a necessities of life, in winter, winter use, should be timely shutdown to ensure the normal use of the boiler next year.
  紧急停车是指紧急情况,即停止锅炉的运行,以防止事故的发生。
  Emergency shutdown refers to an emergency, i.e. stopping the operation of the boiler in order to prevent accidents.
  但对于某些液相有机热载体加热炉停止运行,尤其要注意不要过于粗心和操作不当,使焦炭的温度和热载体劣化,所以停止加热炉停止泵,循环泵的油温一直低于70℃降到目前。要暂时停止炉内压火较长时间,应注意通风,避免焚烧炉、炉圈等。
  But for some liquid-phase organic heat carrier heaters to stop operation, especially care should not be too careless and improper operation, so that the coke temperature and heat carrier deterioration, so stop heating furnace pump, circulating pump oil temperature has been lower than 70 degrees Celsius to the present. In order to temporarily stop pressing fire for a long time, attention should be paid to ventilation to avoid incinerators, furnace rings and so on.
热风炉生产厂家
  节能型锅炉锅炉管破裂泄漏不严重,能保持锅炉水位。在事故不扩大的情况下,可在短时间内减轻负荷,维持运行,待待加热炉启动后即可停止使用。
  The burst and leakage of energy-saving boiler tube is not serious, and the water level of the boiler can be maintained. If the accident does not expand, the load can be reduced in a short time, the operation can be maintained, and the heating furnace can be stopped after starting.
  锅炉爆管后水位无法维持时,应紧急停机。但引风机不应停止,应继续向锅炉加水以降低管壁温度,以免事故再次扩大。
  When the water level cannot be maintained after the boiler tube burst, it should be shut down urgently. However, the induced draft fan should not stop, and should continue to add water to the boiler to reduce the pipe wall temperature, so as to avoid the accident expanding again.
  锅炉,如由于缺水,管壁过热和爆炸管,应紧急停车,炉,并严格禁止锅炉给水,这个时候应该尽快删除炉内的余烬,减少炉的温度,减少锅炉过热的程度。如果多个锅炉同时供汽,则事故锅炉的主蒸汽管应与蒸汽母管分开。
  Boilers, such as water shortage, tube wall overheating and explosive tubes, should be shut down urgently. Furnace feedwater should be strictly prohibited. At this time, the residual embers in the furnace should be removed as soon as possible to reduce the temperature of the furnace and the degree of boiler overheating. If multiple boilers supply steam at the same time, the main steam pipe of the accident boiler should be separated from the main steam pipe.
返回顶部

版权所有©山东众焱机械有限公司 备案号:鲁ICP备19005667号-1 服务热线:18005415007 流量统计: